TV
Repair Database
|
ITT |
Euro Mono 2 |
dead apart from faint
squeak |
5T10 lop tr
S2000A leaky; 5C38 10nf - 33nf dry joint (depends on model) |
|
ITT |
Euro Stereo2 |
S2000AF line o/p tr int
goes s/c; line dr tr goes o/c |
line driver tfmr |
|
ITT |
EuroMono |
Blank raster with flyback
lines. |
No 185v to CRT base , 5R56
( 4.7R saftet )
o/c. |
|
ITT |
EuroMono |
Int picture floods red with
flyback lines. |
IC1002 ( TEA5101A ) on
CRT base. |
|
ITT |
EuroMono |
No colour. |
13IC04 ( Tvp02066 Em0302 )
Pt No.3779-12-24 ) |
|
ITT |
Euromono 2 |
Lack of height from cold |
6C10 220µ 35v |
|
ITT |
FT110 |
Colour - phasing varing. |
C818. |
|
ITT |
FX5532 Euromono |
Lack of height from cold
( about 1 inch ) , clearing |
6C10 ( 220UF , 35V
) in the flyback boost
voltage generator network associated with the TDA8170 field output chip
6IC02. |
|
ITT |
FX6320 CORE 2 |
Dead |
D502 ( BY448 ) by
LOPT |
|
ITT |
FX6332 |
DEAD , EHT STARTS TO RISE BUT STOPS AFTER SECS |
OC44 ( 1000mfd 16v
) IN POWER SUPPLY |
| ITT |
Ideal color 3332GR |
Won't start, going to stby. |
Change polyester cap C709 connected between B-E of
horizontal output Tr. Shorts hor. drive to ground |
| ITT |
Ideal color 3332GR |
Won't start, going to stby. |
Change polyester cap C709 connected between B-E of
horizontal output Tr. Shorts hor. drive to ground |
|
ITT |
LATE SLIM Slimline |
WONT ALWAYS START
, COMES ON WHEN WARM |
CHECK 4.7mfd 400v POWER |
|
ITT |
Mini |
St/by only |
1A fuse Si651 o/c, T713
chopper tr BU508A s/c - C701 4µ7 o/c |
|
ITT |
Mini 2 |
Colour saturation pulsing
when playing tapes |
Also affected e-e to a
lesser extent - TDA3561 decoder chip |
|
ITT |
Mono B |
NO PICTURE OR SOUND WHEN
SWITCHED ON SET HOWLS ,
S |
C722 470uF 16v |
|
ITT |
Mono B |
NO S/V - ALL SUPPLIES INC
EHT PRESENT NO RESET PUL |
C722 470mfd , 16v |
|
ITT |
Mono B |
TRIPS WITH MOMENTARY
DISPLAY |
C715 1000mfd |
|
ITT |
Mono B |
WON'T COME ON FROM COLD
AFTER 3-4 TRIES SET COMES |
C707 2.2uF |
|
ITT |
Monoprint A |
Dead |
LOPTx u/s - ok on dummy
load |
|
ITT |
Monoprint B |
Comes on with a screech |
C901 4µ7 400v & C707 2µ2
63v |
| ITT |
Monoprint B |
Cuts out & int loses
chan memory |
5v reg IC1405 |
|
ITT |
Monoprint B |
dead |
HT at LOP Tr low at 25v;
C701 4µ7 400v low cap (HT smoother) |
|
ITT |
Monoprint B |
Dead |
Dry joints pin Q of chopper
tfmr |
|
ITT |
Monoprint B |
Dead |
T501 BU508A LOP tr leaky,
dry joint C518, C712 47µ 16v hi esr |
| ITT |
Monoprint B |
Dead |
D733, IC701, R715, R721,
D702 |
|
ITT |
Monoprint B |
Dead - 115v at BU508D
collector. |
Try LOPTX see Tv mag. |
| ITT |
Monoprint B |
Dead - low HT & no EHT |
LOPTx - scope LOPTr coll - has lots of spikes |
|
ITT |
Monoprint B |
Dead - no 115v feed to line
stage. |
C701 ( 4.7u f ) in
PSU. |
| ITT |
Monoprint B |
Dead - pri psu ok |
D733 & C734 |
| ITT |
Monoprint B |
Dead - tripped |
LOPTx or s/c LOP stage |
|
ITT |
Monoprint B |
How switch mode PSU works. |
With ccts. |
| ITT |
Monoprint B |
Int dead |
Dry joints chopper tfmr |
|
ITT |
Monoprint B |
No cold start |
C722 470µ 16v (8v
smoother)- NOTE wrong markings on pcb top |
| ITT |
Monoprint B |
No control via front
controls |
Keypad defective - try
cleaning |
| ITT |
Monoprint B |
No sound |
C304 470µ (pin 5 TDA8196 IC301) |
|
ITT |
Monoprint B |
Pic pulling/flickering - OK
on Scart |
C201 4µ7 in tuner hi esr |
|
ITT |
Monoprint B |
Sizzling noise followed by
thump then Dead. |
Pin G of chopper Tx dry. |
| ITT |
Monoprint B |
Slow start up |
C701 & C707 |
|
ITT |
Monoprint B |
Slow start up from cold. |
Change C701 , C722
( 470u f 16v ) , C711 , C707 , R512 |
|
ITT |
Monoprint B |
Slow startup. |
C704 ( 47u f ) ,
C701 ( 4.7u f ) may check Ok. |
|
ITT |
Monoprint B |
St/by only |
HT at chopper Tr - Replace
C701 4µ7 400v o/c; BU508A LOP Tr leaky |
| ITT |
Monoprint B |
St/by only |
C715 |
| ITT |
Monoprint B |
St/by only with EHT present |
C722 |
| ITT |
Monoprint B |
Txt inoperative - indicator
works |
DPU2540 chip on txt panel |
|
ITT |
MP37H |
No
sound via tuner - ok via scart |
Surf mount Tr VA02 BC847
leaky b-e - pulled down pin 1 of TDA8362 audio de-emphasis |
|
ITT |
Pico |
Dead - PSU not operating |
ZPY120 120v over volts
zener leaky |
|
ITT |
Pico |
Will not startup - LTB
loaded. |
Disconnect scan coils if
sounds better then LOPTX. |
|
ITT |
Pico 1 |
Dark pic |
TDA3561 u/s |
|
ITT |
PICO 1 |
PICTURE DARK
( NOT A1 SUPPLY
) |
TDA3561 |
|
ITT |
Pico 1A |
Dead - with rapid ticking |
No HT - D658 120v zener
leaky |
|
ITT |
Pico 1A |
Tuning - will not tune in. |
R1154 ( 2.2k ) o/c ,
D1151 ( reads ok ) |
|
ITT |
Pico S |
Bad hum bar & no sound |
Replace 4 x 1N4007 mains
rects |
|
ITT |
Pico S |
Blank raster with line
tearing - sound int |
C524 10µ |
|
ITT |
Pico S |
dead |
2A fuse on front panel o/c;
degauss therm caused it |
|
ITT |
Pico S |
Dead. |
Check small LT transformer
for o/c. |
|
ITT |
Pico S |
Display shows
"88" |
SAA1292 chip faulty -
caused by dry joints esp on C10 1000µ |
|
ITT |
Pico S |
Int dead when heated |
115v HT still present; dry
joints LOP tr |
|
ITT |
Pico S |
Misty pic - poor col with
red flaring |
Earthing ring on crt base
shorting to cathodes |
|
ITT |
Pico S |
No sound |
R1075 3R3 safety res o/c;
C229 220µ s/c |
|
ITT |
Pico S |
Pulling/bouncing/int loss
of sound |
C212 10µ 50v in CMR800
(top of can) |
|
ITT |
Pico S |
St/by only |
relay clicks at sw on but
no HT to LOP Tr; C701 10µ 350v faulty |
|
ITT |
Pico S2 |
Dead - no relay click at
switch on. |
Standby mains transformer
primary winding o/c. |
|
ITT |
Pico S2 |
Dead - no relay click or
display |
Mains st/by tfmr o/c pri |
|
ITT |
Pico S3 |
Dead - life restored if
scan coils dis'd |
Width control coil on scan
coils has shorted turns |
|
ITT |
Pico S3 |
Dead apart from brief led
flicker at sw on |
LOPTx |
|
ITT |
SP71D1 |
Dead with S2000AF lop tr
s/c |
failed aft replacement -
CK51 8n7 1.6kv faulty |
|
ITT |
SP71D1 |
line driver tr VK22 blows
few mins aft sw on |
CK22 2µ2 100v |
| ITT |
ST28TX |
No sound/blank raster - no R/C & corrupt display |
reset line to micro IC701 stuck at 4v. CCU SEL06 &
MDA2061 leaky from reset pins to chassis. No sound caused by D701 1N4148
in mute line leaky. All caused by dry joints on reg chassis connection |
|
ITT |
ST3487 |
No picture. |
IC401 ( TDA2170 ) |
|
ITT |
ST35767 |
Dead |
Field o/p chip had blown |
|
ITT |
ST38767 |
Dead |
TDA2170 field o/p chip s/c |
|
ITT |
ST38767 |
Field bounce |
Dry joints regs |
|
ITT |
ST38767 |
No pic - sound ok |
TPU2732 Txt proc chip |
|
ITT |
Trimline |
122v rail going low after
1/2 hour. |
Change T617
( BC238 ) . |
|
ITT |
Trimline |
Bars across screen about
1" wide. |
C1425 ( 2.2uf ) o/c. |
|
ITT |
Trimline |
Blank raster. |
T400 ( BC237 ) or
( BC171 ) part of beam
limiter cct. |
|
ITT |
Trimline |
Dead - relay clicks on -
mains on board. |
Black fat MR856
( or BYT13/600 ) diode by LOPTX. |
|
ITT |
Trimline |
Standby - stuck in standby. |
TR1401 o/c ,
on CMC301. |
|
ITT |
Trimline |
Standby - stuck on standby. |
Standby mains transformer
Tr1401 o/c. |
|
ITT |
Trimline |
Standby - switching to
standby. |
C1419 leaky on CMC301. |
|
ITT |
Trimline |
Tuning - no tuning. |
No tuning volts , C1072 o/c
, T1414 leaky. |
|
ITT |
TX2713 |
Frame - line 2 1/3 way
down. |
Drys on frame earth. |
|
ITT |
TX3126 |
TRIPS AT SWITCH ON |
C715 1000uF |
|
ITT |
TX3325 2-ST2 |
Blank raster. |
D402 s/c. |
|
ITT |
TX3325 2-ST2 |
Bright raster & flyback
lines. |
Short circuit in CRT. |
|
ITT |
TX3325 2-ST2 |
Tripping
( fast ) at switch on
then dead. |
D702 5v1 zener , R716. |
|
ITT |
TX3325 2-ST2 |
White raster - sound ok. |
Replace D504 , D505 &
R514. |
|
ITT |
TX3326 Mono B |
No text - green text light
always on. |
DPU2541 IC ON TEXT PCB |
|
ITT |
TX3426 Comp B |
Dead - 1 clunk then standby
LED fades out. |
LOPTX D050/37. |
|
ITT |
TX3426 Comp B |
No colour. |
C891 s/c ,
IC800. |
|
ITT |
TX3437 Comp B |
Dead - fuse Ok. |
On/off switch o/c. |
| ITT |
TX3446 |
Blank raster |
Comp vid present on dig vid board - ok entering VCU2100A
vid codec chip but no o/p - chip faulty |
|
ITT |
TX3446 |
Dead - Chopper tr s/c &
Fu01 shattered |
C712 10µ 400v |
|
ITT |
TX3446 |
Line tearing & int
sound mute |
C209 10µ & C231 0µ47
in tuner |
|
ITT |
VC200 |
Dead. |
LOPTX |
|
ITT |
VC301 |
Sync - no sync - noisy
volume , eht arced |
R100 ( 1MR )
o/c. |
